活动断裂带大调整量无砟轨道设计与试验研究<sup>*</sup>

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (1181 KB) HTML (0 KB)
输出: BibTeX | EndNote (RIS)

摘要 研究目的： 为满足跨活动断裂带线路铺设无砟轨道需求,提升该地区无砟轨道的线路平顺性与舒适性,提出一种大调整量活动承轨台式无砟轨道。采用ANSYS有限元软件建立整体和轨枕局部有限元模型,分析活动承轨台式无砟轨道的受力特性,在此基础上进行大调整量无砟轨道结构参数优化研究以及疲劳试验研究,分析结构刚度、位移和应变变化情况。
研究结论： （1）活动承轨台式无砟轨道在列车荷载与温度荷载叠加作用下,最大拉应力出现在轨枕位置,为3.47 MPa,各部件应力均满足强度要求且在轨枕尺寸和材料优化后进一步降低;（2）疲劳试验中随着疲劳加载次数增加,结构横、纵向刚度在疲劳前后变化分别为3.4%和24.2%,结构应变小幅增加,未见塑性变形与明显损伤;（3）仿真与试验结果可为活动断裂带地区无砟轨道设计提供参考和借鉴。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张政

关键词 ：活动断裂带, 无砟轨道, 大调整量, 结构参数优化, 疲劳试验

Abstract：Research purposes: To meet the need for laying ballastless track across active fault zones and improve the smoothness and comfort of ballastless track in this area, a ballastless track with a large adjustable bearing table was proposed. The integral and local finite element models of the sleeper were established using ANSYS finite element software to analyze the mechanical characteristics of the track. Based on the analysis, the structural parameter optimization and fatigue test of ballastless track with large adjustment were carried out, and the changes of structural stiffness, displacement and strain were analyzed.
Research conclusions: （1）Under the superposition of train load and temperature load, the maximum tensile stress at the sleeper position is 3.47 MPa, and the stress of each component meets the strength requirements and further decreases after the sleeper size and material optimization. （2）In the fatigue test, with the increase of fatigue loading times, the transverse and longitudinal stiffness of the structure before and after fatigue changes are 3.4% and 24.2%, respectively. The structural strain increases slightly, and no plastic deformation and obvious damage are found. （3）The simulation and test results can provide reference for the design of ballastless track in active fault zone.

Key words： active fault zone ballastless track large adjustment structural parameters optimization fatigue test

收稿日期: 2024-04-16

PACS:

U213.2

基金资助:中铁第四勘察设计院集团有限公司科技研发课题（2022K105,2022K032,KY2023119D）

作者简介: ^**张政,1987年出生,男,高级工程师。

引用本文:

张政. 活动断裂带大调整量无砟轨道设计与试验研究^*[J]. 铁道工程学报, 2024, 41(6): 45-51.
ZHANG Zheng. Design and Experimental Study of Ballastless Track with Large Adjustment in Active Fault Zone. Journal of Railway Engineering Society, 2024, 41(6): 45-51.

链接本文:

https://tdgcxb.crec.cn/CN/ 或 https://tdgcxb.crec.cn/CN/Y2024/V41/I6/45

[1]	张永双, 任三绍, 郭长宝, 等.活动断裂带工程地质研究[J]. 地质学报, 2019(4): 763-775.Zhang Yongshuang, Ren Sanshao, Guo Changbao, etc. Research on Engineering Geology Related with Active Fault Zone[J]. Acta Geologica Sinica, 2019(4): 763-775.
[2]	李国和. 郯庐断裂带苏鲁段新构造区划与铁路选线研究[J]. 铁道标准设计, 2021(7): 14-21.Li Guohe.Research on Railway Route Selection and Neotectonic Zonation in Tan-Lu Fault Zone of Shandong-Jiangsu Section[J]. Railway Standard Design, 2021(7): 14-21.
[3]	柏华军. 郯庐断裂带对徐连高铁的影响及工程应对措施[J]. 铁道标准设计, 2021(4): 46-51.Bai Huajun.The Impact of the Tanlu Fault Zone on the Xuzhou-Lianyungang High-speed Railway and Engineering Response Measures[J]. Railway Standard Design, 2021(4): 46-51.
[4]	蔡向辉, 于鹏, 周红丽, 等. 活动断裂带地区地铁新型轨道结构动力响应研究[J]. 铁道标准设计, 2017(12): 14-19.Cai Xianghui, Yu Peng, Zhou Hongli, etc. Research on Dynamic Response of Metro Track Structure in Active Fault zone[J]. Railway Standard Design, 2017(12): 14-19.
[5]	任娟娟, 刘伟, 庞玲, 等. 大调整量新型高承轨台无砟轨道受力特性[J]. 铁道工程学报, 2021(5): 31-35.Ren Juanjuan, Liu Wei, Pang Ling, etc. Mechanical Characteristics of New High Rail Bearing Platform Ballastless Track with Large Adjustment Ability[J]. Journal of Railway Engineering Society, 2021(5): 31-35.
[6]	李莹, 杨荣山, 钟泽方, 等. 高速铁路新型大调整量弹性长枕式无砟轨道结构研究[J]. 铁道标准设计, 2021(12): 12-16.Li Ying, Yang Rongshan, Zhong Zefang, etc. Study on the New Large Adjustment Long Elastic Sleeper Ballastless Track for High-speed Railway[J]. Railway Standard Design, 2021(12): 12-16.
[7]	刘伟斌. 高速铁路变形可调板式无砟轨道结构研究[J]. 铁道建筑, 2022(1): 18-21.Liu Weibin.Study on the Structure of Deformable Plate-type Ballastless Track of High Speed Railway[J]. Railway Engineering, 2022(1): 18-21.
[8]	徐红, 于鹏, 许正洪, 等. 城市轨道交通活动断层区域用宽枕板试制及试验研究[J]. 铁道标准设计, 2018(1): 64-68.Xu Hong, Yu Peng, Xu Zhenghong, etc. Trial Manufacture and Experimental Research of Broad Sleeper Slab in Active Fault Zone[J]. Railway Standard Design, 2018(1): 64-68.
[9]	贠剑峰. 一种可适应轨道基础大变形的无砟轨道结构研究[D]. 兰州:兰州交通大学, 2021.Tai Jianfeng.Study on a Ballastless Tracks Structure That Can Adapt to the Settlement of Track Foundation[D]. Lanzhou:Lanzhou Jiaotong University, 2021.
[10]	谭诗宇. 活动断裂带隧道内轨道结构振动传递特性及结构选型研究[D]. 北京:北京交通大学, 2017.Tan Shiyu.Study on Vibration Transfer Characteristics and Structure Selection of Railway Track in Active Fault Zone Tunnels[D]. Beijing:Beijing Jiaotong University, 2017.
[11]	沈建明. 客运专线铁路跨越断裂带有关问题探讨[J]. 铁道工程学报, 2011(10): 30-37.Shen Jianming.Study on Relevant Issues on Passenger Dedicated Railway Crossing Fault Zone[J]. Journal of Railway Engineering Society, 2011(10): 30-37.
[12]	TB 10082—2017,铁路轨道设计规范[S].TB 10082—2017, Code for Design of Railway Track[S].